Legend Tuned · Chip Tuning
Volvo S80 (Gen 2) 1.6D DRIVe 109 HP Chip Tuning
- 2006–2016
- Diesel
- 109 HP · 240 Nm
- ECU: Bosch EDC16CP31
Target with Legend Tuned Stage 1: 135 HP / 295 Nm. The original software is backed up, the calibration is tailored to the car, and the result is verified by datalog.
Legend Tuned figures
Stage 1Figures are examples/estimates and may vary with the car's mileage, maintenance condition, fuel quality and hardware. Exact results are determined by dyno/datalog.
Power & torque curve
Stock vs Stage 1 comparison
A representative power and torque curve with a technical table of all figures. Hover over the chart to see values by rpm.
- Power · Stage 1
- Torque · Stage 1
- Power · Stock
- Torque · Stock
Technical figures
| Value | Stock | Stage 1 |
|---|---|---|
| Power | 109 HP | 135 HP |
| Power (kW) | 80 kW | 99 kW |
| Torque | 240 Nm | 295 Nm |
| Power gain | — | +26 HP (+24%) |
| Torque gain | — | +55 Nm (+23%) |
Figures are examples/estimates and may vary with the car's mileage, maintenance condition, fuel quality and hardware. Exact results are determined by dyno/datalog.
Custom software · 5 options
Custom software options for this engine
Legend Tuned functions suitable for this engine, which can be applied in the same session as Stage software or on their own.
Emission Systems
Emission system solutions for track and motorsport projects.
- DPF/FAP Delete A motorsport-focused software solution for the faults, power loss and limp mode caused by a clogged diesel particulate filter (DPF/FAP).
- EGR Delete A software solution for the smoke, power loss and check-engine light caused by a carboned-up, failing EGR valve.
Legal notice: Software for emission systems (catalytic converter, DPF/FAP, OPF, EGR, AdBlue/SCR, etc.) is intended solely for track / motorsport and closed-course use. Driving vehicles with these systems disabled on public roads, and presenting them for TÜVTÜRK inspection, may be against regulations. On request, the original software can be restored.
Driving & Sound Effects
Make yourself heard and be first off the line.
Fault & Function Solutions
Permanent software fixes for annoying faults.
Stage 2 hardware, peace of mind and process
After Stage 1
Stage 2 is not listed for this engine
There's no meaningful Stage 2 figure for this engine; most of the gain comes with Stage 1 software. For livelier throttle response and a deeper intake sound, you can complement Stage 1 with the Custom Sport Filter Kit.
Included every time
Power with peace of mind
- Original software backup — the factory software is read and archived before the job.
- Reversal — the car can be returned to its original software whenever you ask.
- Datalog check — boost pressure, ignition and air/fuel ratio are recorded and checked on a road test.
- Vehicle-specific calibration — not an off-the-shelf file; tuned to the engine, hardware and fuel quality.
- Pre-tune diagnostics — fault memory is read and engine health is checked before the software.
-
Book
Tell us about your car and your goals; we'll plan the day and time together.
-
Analysis & backup
Fault memory is read, the ECU is identified and the original software is archived.
-
Legend Tuned software
Calibration tailored to the car (Stage 1: ~1–2 hours).
-
Test & handover
Verified with a road test + datalog, then handed over with a walkthrough of what was done.
Volvo S80 (Gen 2)
Other engines in the same generation
- Petrol 2.0 145 → 155 HP +10
- Petrol T4 1.6 180 → 230 HP +50
- Petrol 2.5T 200 → 245 HP +45
- Petrol 2.0T 203 → 270 HP +67
- Petrol 2.5T 231 → 260 HP +29
- Petrol 3.2 238 → 250 HP +12
- Petrol T5 2.0 240 → 270 HP +30
- Petrol 3.2 243 → 260 HP +17
- Petrol T5 2.0 Drive-E 245 → 300 HP +55
- Petrol T6 3.0 AWD 285 → 310 HP +25
- Petrol T6 3.0 AWD 304 → 330 HP +26
- Petrol V8 4.4 AWD 315 → 335 HP +20
- Diesel D2 1.6 115 → 145 HP +30
- Diesel 2.0D 136 → 172 HP +36
- Diesel 2.4D 163 → 205 HP +42
- Diesel D3 2.0 (5-Cylinder) 163 → 185 HP +22
- Diesel 2.4D 175 → 200 HP +25
- Diesel D4 2.0 (5-Cylinder) 181 → 230 HP +49
- Diesel D4 2.0 Drive-E 181 → 230 HP +49
- Diesel D5 2.4 185 → 220 HP +35
- Diesel D4 2.0 Drive-E 190 → 235 HP +45
- Diesel D5 2.4 205 → 225 HP +20
- Diesel D5 2.4 215 → 260 HP +45
Other S80 generations
Vehicle Selector